Material Safety Data Sheet


TRICURE II
IDENTITY (as used on label and list)
SAF-T-LOK TRICURE II
Manufacturer’s name
SAF-T-LOK CHEMICAL CORPORATION
300 EISENHOWER LANE NORTH
LOMBARD, ILLINOIS, USA 60148		 Emergency Telephone Number
Chemtrec 1-800-424-9300
Telephone Number for Information
630-495-2001
Date Prepared
NOVEMBER 01, 2007
Section II—Hazardous Ingredients/Identity Information
Hazardous Components
(Specific Chemical Identity, Common Name(s))
OSHA PEL
ACGIH TLV

Other Limits Recommended
% (optional)
Acrylic acid  
   10ppm    
   
       
   
       
All components of this product are listed on the Toxic Substance Control Act (TSCA) inventory of chemical substances maintained by the U.S. Environmental Protection Agency.
 

Section III—Physical/Chemical Characteristics
Boiling Point 200°F Specific Gravity (H20 = 1)     1.11
Vapor Pressure (mm Hg) @ 30°F 6 Melting Point N/A
Vapor Density (AIR = 1) <1 Evaporation Rate (Butyl Acetate = 1) N/A
Solubility in Water Insoluble
Appearance and Odor Amber liquid, faint odor

 

Section IV—Fire and Explosion Hazard Data
Flash Point (Method Used)

(Pensky-Martins)
Over 200°F
Flammable Limits  
LEL  N/A
UEL N/A
 

Extinguishing Media

 Carbon Dioxide, dry chemicals, foam
Special Fire Fighting Procedures Use air supplied mask and procedure for chemical fires.
Unusual Fire and Explosion Hazards Toxic fumes (oxides of carbon and nitrogen) may be evolved upon exposure to heat or open flame.
 
Section V—Reactivity Data
Stability Unstable   Conditions to Avoid
Storage in open containers, exposure to heat and/or open flame exposure to incompatible substances.
Stable X
Incompatibility (Materials to Avoid) Strong oxidizers, amines, strong Lewis or mineral acids, thiosulfates. Considerable smoke and toxic fumes may be evolved as a result of uncontrolled exothermic reactions if large masses of material react with curing agents (peroxides or amines).
Hazardous Decomposition or Byproducts  
Hazardous
Polymerization		 May Occur   Conditions to Avoid    
Will not Occur X
 
Section VI—Health Hazard Data
Route(s) of Entry: Inhalation?
Yes		 Skin?
Yes

 Ingestion?
Yes
Health Hazards (Acute and Chronic)

Excessive inhalation of vapors can cause nasal and respiratory irritation. See symptoms below.
Carcinogenicity: N/A

       
NTP?
 		 IARC Monographs?
 		 OSHA Regulated
 

 
Signs and Symptoms of Exposure

INHALATION: Dizziness, weakness, nausea, headache, possibly unconsciousness. CONTACT WITH EYES: Can cause severe irritation, redness, tearing, blurred vision. SKIN: Prolonged or repeated contact can cause irritation & dermatitis. INGESTION: Gastrointestinal irritation, nausea, vomiting.
Medical Conditions Generally aggravated
by Exposure

None known.
Emergency and First Aid Procedures

INHALATION: Remove to fresh air, if breathing has stopped, give artificial resp. & get medical attention. DO NOT give stimulants. EYE CONTACT: Flush with water, see physician. INGESTION: Do not induce vomiting, call physician. SKIN CONTACT: Wash with soap and water.
 
Section VII—Precautions for Safe Handling and Use
Steps to be Taken in Case Material is
Released or Spilled

Provide adequate ventilation. Absorb material with vermiculite, sand or other inert absorbing material and shovel into container.
Waste Disposal Method

Contaminated absorbent may be deposited in a landfill in accordance with Local, State and Federal regulations.
Precautions to be Taken
in Handling and Storing

Do not use in poorly ventilated or confined spaces. Keep containers tightly closed when not in use. Store in a cool, dark area away from heat and flames. Temperatures over 120°F should be avoided for maximum shelf life. DOT & AITA Hazard Classification: Not restricted Article.
Other Precautions

 
 
Section VIII—Control Measures
Respiratory Protection (Specify Type)

Respiratory equipment is unnecessary in normal use. If TLV is exceeded use approved air supplied respirator.
Ventilation:
Local Exhaust Yes
Special N/A
Mechanical (General) If needed
Other N/A
Protective Gloves Polyethylene or polyvinyl
Eye Protection Safety glasses, face shield
Other Protective Clothing or Equipment

Eye wash fountain
Work/Hygienic Practices

Avoid prolonged breathing of vapors or contact with eyes. Do not take internally.

The information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions. Any use of the product which is not in conformance with this data sheet or which involves using the product in combination with any other product or any other process is the responsibility of the user.